Equipment Operator Semi-Skilled (Wastewater Collections)

Job Summary

Under general supervision visually inspects equipment to ensure proper operating condition, performs minor lubrication services; reports major malfunctions or repairs needed to supervisor; operates equipment to include tractor with rotating cutter and various hand held equipment; positions necessary safety equipment around worksite to avoid possible hazards; locates and identifies utility lines before digging or installing sewer mains; inspects worksite to ensure specifications are met and equipment has been properly installed and performs additional tasks in support of the department as needed or upon request.

Essential Job Duties & Responsibilities

The following duties are normal for this position. The omission of specific statement of the duties does not exclude them from the classification if the work is similar, related, or a logical assignment for this position. Other duties may be required, assigned and expected aside from those set forth below to address operational needs and changing operational practices.

• Visually inspects back hoe and equipment to ensure no problems are existing.
• Checks fluid levels to include oil, water and hydraulic fluids; adds additional fluid as needed.
• Performs minor repairs on equipment to include replacing blown lights, bulbs, and fuses.
• Reports major equipment malfunctions or repairs or needed to supervisor for repair by shop mechanic. Visually inspects tires to ensure no wear or damaged is visible; using air pressure gauge tests to ensure tires are properly inflated.
• Inspects exterior of vehicle and equipment lights and replaces broken or damaged parts as necessary. Using a grease gun performs lubrication services on equipment.
• Inspects fittings and joints on equipment to ensure they are serviceable.
• Using a pressure washer, brush and cleaning solution cleans exterior of vehicles and equipment to remove mud, dirt and debris.
• Operates various equipment to include pumps, tamps, saws, jetters, and vactors.
  Positions necessary safety equipment around work area to avoid safety hazards to include safety cones, signs and flares; may position flag person to direct traffic.
• Ensures that signaling and beacon lights are operating when work is in progress.
• Uses two-way radio to communicate with superintendent, dispatchers, and other work crews.
• Operates tractor with rotating cutter to cut sewage right-of-way and lift station grounds.
• Loads sand, gravel and heavier debris into trucks for transport.
• Operates hand held packer to re-pack dirt upon completion of repairs.
• Takes safety precautions not to damage existing water mains or other utilities when working near live lines to include electrical and gas lines fiber optic (telephone) lines.
• Uses chain saw to cut trees and low hanging limbs in right of ways; may cut larger debris before loading for dumping at the landfill.
• Uses jackhammer to break pavement or concrete to access sewer lines in need of repair.
• Receives daily work assignment from foreman; gathers materials and supplies before leaving for work site.
• Confers with utility personnel to ensure that lines have been located and identified before beginning work.
• Installs sewer mains and service lines for residential and commercial properties.
• Assists in installing sewage water pumps at lift stations.
• Uses gas powered pipe saw to cut pipe used in sewer line repairs; assist in asphalt repairs.
• Assists in performing various pipe fitting tasks, may raise and rebuild man holes.
• Forms, mixes, and pours concrete to replace areas of driveways or sidewalks, damaged or removed to make repairs or installations.
• Performs additional tasks as assigned or upon request.

Qualifications

Education & Experience Guidelines
Any combination of education and experience that would likely provide the required knowledge and abilities is qualifying. A typical way to obtain the knowledge and abilities required for this position would be:

Education/Training
High school education, GED or demonstrated level of proficiency.

Experience
N/A

Licenses or Certifications Required
Meet appropriate certification requirements. Valid State Issued Driver’s License required.

The following generally describes the knowledge and abilities required in order to successfully perform the assigned duties of the position:

Knowledge of:

• Waste water design and operations including installation, maintenance and repair.
• Organization and operational procedures of waste water division of utilities department.
• Various tools and equipment including, tamps air hammers and pipe saws.

Ability to:

• Comprehend operator manuals, directives, gauges and indicators.
• Prepare reports, work orders and similar non-complex documents.
• Converse with supervisors and co-workers on work related issues.
• Count, add and subtract whole numbers.
• Safely and efficiently operate jackhammer to access sewer lines.
• Operate chain saw to cut low hanging limb or other debris from right-of -ways.
• Operate gas powered pipe saw to cut pipe used in sewer line repairs.
• Exercise judgement particularly in tasks involving safety of self and others or efficiency of operations.
• Follow instructions and efficiently complete tasks.
• Work as a member of a team.

Physical Demands & Working Environment

The conditions herein are representative of those that must be met by an employee to successfully perform the essential functions of this job. In compliance with the Americans with Disabilities Act, the city encourages both prospective and current employees to discuss potential accommodations needed to perform the essential duties of this position.

Environment: Work performed primarily outdoors.

Physical Demands: See accompanying page for details

Key Working Relationship:  Supervisors, co-workers and other City employees.

Applications for this position will be accepted until a pool of 20 applications is received or the position is filled, whichever comes first. Current city employees wishing to apply should send Internal Job Application provided by the Human Resources Department to the HR Director by the deadline stated. (A courtesy copy will be sent to the employee’s department head.)

Applications can be found online (download an application) or picked up at the City of Phenix City Human Resources Department:
1103 Broad Street
Phenix City, AL 36867
Ph: 334 448-2706

Applications are available for pick up and drop off on Mondays from 2 to 5 p.m., Eastern Time, and Tuesdays, Wednesdays, and Thursdays from 10 a.m. until 2 p.m., Eastern Time. You may also email your completed application with the required supporting documents.